Product ID:MIL-H-6083D HYDRAULIC FLUID
MSDS Date:10/01/1986
FSC:9150
NIIN:00-935-9810
MSDS Number: BJNXW

Emergency Phone: 504-362-3232

Info Phone: 504-362-3232

Cage: 27978

Telephone: 504-362-3232, OR 800-535-4095

Cage: 27978

"NOT HAZARDOUS"

Fraction By Weight: 100%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARDS: EYE-MAY CAUSE
IRRITATION. SKIN-IRRITATION. INHALE-MAY CAUSE LOCAL IRRITATION.
INGEST-MAY CAUSE LOCAL IRRITATION OF THE MUCOUS MEMBRANE OF THE
MOUTH, ESOPHAGUS AND STOMACH.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:OVEREXPOSURE: EYE-BURNING. SKIN-DERMATITIS.
INHALE-DROWSINESS, PNEUMONIA OR COMA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN: REMOVE SOILED CLOTHING. WASH AREA WITH SOAP AND WATER.
INHALE: REMOVE TO FRESH AIR IMMEDIATELY. IF BREATHING STOPS, GIVE
CPR & OXYGEN. SEE A DOCTOR IMMEDIATELY. EYE: FLUSH WITH LARGE
AMOUNTS OF WATER FOR 15 MINUTES. CALL A DOCTOR IMMEDIATELY.
INGEST: DO NOT INDUCE VOMITING. CALL A DOCTOR IMMEDIATELY.

Flash Point Method:COC
Flash Point:200F,93C
Autoignition Temp:Autoignition Temp Text:600F
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:TREAT AS OIL FIRES. USE WATER ONLY TO COOL
SURROUNDING CONTAINERS OF FLAMMABLE OR COMBUSTIBLE MATERIAL.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHEN
BURNING. PRODUCTS OF COMBUSTION-CO, CO2. SMOKE, SOX.

Spill Release Procedures:SPILL-SCRAPE UP MATERIAL INTO WASTE CONTAINER
OR ABSORB WITH DRY SAND OR OIL ABSORBENTS. CLEAN SPILL AREA WITH
DETERGENT SOLUTION OR SAFETY SOLVENTS. PROVIDE ADEQUATE
VENTILLATION DURING CLEAN UP.

Handling and Storage Precautions:STORAGE-STORE IN SEALED CONTAINER AWAY
FROM HEAT, OPEN FLAME, & OXIDIZING MATERIALS. FIRE EXTINGUISHERS
MUST BE KEPT READILY AVAILABLE.
Other Precautions:DO NOT TRANSFER TO UNMARKED CONTAINER. FOLLOW DOT
REGULATIONS DURING TRANSPORT. PROPRIETARY CHEMICALS OBTAINED FROM
VARIOUS MANUFACTURERS ARE ADDED TO THIS PRODUCT. THESE ADDITIVES
HAVE BEEN DESIGNATE D AS NONHAZARDOUS BY THE MANUFACTURERS.

Respiratory Protection:LOW CONCENTRATION MIST-USE HALF-MASK OR FULL
FACE PIECE RESPIRATOR WITH REPLACEABLE CARTRIDGE FILTER. HIGH
CONCENTRATION MIST-USE FULL FACE SUPPLIED AIR RESPIRATORY IN
POSITIVE PRESSURE MODE OR FULL F ACE SCBA WITH POSITIVE PRESSURE.
Ventilation:ADEQUATE VENTILATION IN ACCORDANCE WITH GOOD ENGINEERING
PRACTICE MUST BE PROVIDED.
Protective Gloves:SYNTHETIC RUBBER GLOVES
Eye Protection:PLASTIC FACE SHIELD/CHEMICAL SPLASH
Other Protective Equipment:SYNTHETIC RUBBER PROTECTIVE CLOTHING, BOOTS,
ETC. MAY BE WORN TO PROTECT THE BODY.
Work Hygienic Practices:WASH HANDS AND FACE WITH SOAP AND WATER BEFORE
SMOKING OR EATING.
Supplemental Safety and Health

HCC:V6
Boiling Pt:B.P. Text:440F,227C
Vapor Pres:<1
Spec Gravity:0.86
Evaporation Rate & Reference:1 (EE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED LIQUID, PETROLEUM ODOR
Percent Volatiles by Volume:NIL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE

Waste Disposal Methods:WASTE MATERIAL SHOULD BE DUMPED OR BURIED IN AN
APPROVED INDUSTRIAL WASTE LAND FILL. LARGE QUANTITIES MAY BE
DISPOSED OF BY INCINERATION IN A SUITABLE COMBUSTION CHAMBER.
DISPOSAL MUST COMPLY WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.